基于CY8CLEDAC02的17W LED驅動器設計方案
時間：2010-04-08 01:52:31
關鍵字：
DAC
EDA
LED驅動器
PROTECTION
手機看文章
掃描二維碼
隨時隨地手機看文章
[導讀]Cypress 公司的CY8CLEDAC02高性能離線LED驅動器,器件采用有所有權的數控技術,能自動檢測調光類型. CY8CLEDAC02 AC離線輸入從80VAC到277VAC,輸出功率高達25W,調光范圍從2%到100%.主要用在可調光的離線LED驅動器,LED替
Cypress 公司的CY8CLEDAC02高性能離線LED驅動器,器件采用有所有權的數控技術,能自動檢測調光類型. CY8CLEDAC02 AC離線輸入從80VAC到277VAC,輸出功率高達25W,調光范圍從2%到100%.主要用在可調光的離線LED驅動器,LED替代燈以及LED照明.本文介紹CY8CLEDAC02主要特性,方框圖, 簡化的應用方框圖, 調光輸入的LED驅動電路圖以及采用CY8CLEDAC02 120VAC 17W可調光LED驅動器參考設計電路圖和材料清單.
The CY8CLEDAC02 is a high performance offline LED driver, designed to interface directly with most conventional phase cut based wall dimmers. The device uses proprietary digital control technology to provide automatic detection of dimmer type(leading or trailing edge). It automatically generates dimming signals for LED loads and has the ability to dim down to 2%. It modulates LED brightness using a linear dimming scheme and switches to a PWM based dimming scheme for output current levels lower than 20% of the full load current. In PWM mode optimized dimming frequencies in the range of 900 Hz result in zero visible flicker.
At the heart of a CY8CLEDAC02 based system is the chopping circuit which provides the load necessary to enable correct wall dimmer operation. It also improves PF when there is no dimmer on the line.
The devices’ proprietary primary side sensing enables tight LED current regulation and eliminates the need for secondary feedback circuitry. No opto-couplers are necessary to meet UL isolation requirements; enabling flyback conversion with automatic isolation.
The CY8CLEDAC02 operates in quasi-resonant mode to achieve high efficiency. This mode of operation helps minimize external component count and simplifies EMI design, lowering the total bill of material cost.
The device’s cycle-by-cycle adaptive digital regulation uses critical discontinuous conduction mode (CDCM) when driving LED loads. The control algorithm for cycle-by-cycle regulation has internal compensation for guaranteed system phase and gain margins; requiring no external components for loop compensation.
The CY8CLEDAC02 has full featured circuit protection not normally available with other primary-side control solutions. The built-in protection includes output overvoltage protection (OOVP), output short circuit protection (OSCP), overtemperature protection (OTP), current-sense resistor short protection (CSSP), and peak current limit protection (PCLP). It also enables automatic LED brightness adjustment to compensate for temperature drift by simply connecting a NTC resistor to the VT pin.
CY8CLEDAC02主要特性:
■ AC offline input range from 80 to 277 VAC
■ Up to 25W output power range
■ Intelligent wall dimmer detection:
❐ Leading edge (R, RL) dimmers
❐ Trailing edge (RC, RLC) dimmers
❐ No dimmer
■ Wide dimming range from 2 to 100%
■ Resonant control to achieve high efficiency (85% without dimmer)
■ Meets harmonic requirement with high power factor (0.7 without dimmer)
■ Primary-side sensing eliminates opto-isolators
■ Tight LED current regulation (typically < + 2.5%)
■ Low startup current (typically 10 A)
■ Low startup time (typically 0.5s with active startup)
■ Multiple protection features:
❐ Output overvoltage protection (OOVP)
❐ Output short circuit protection (OSCP)
❐ Overtemperature protection (OTP)
❐ Current-sense resistor short protection (CSSP)
❐ Peak current limit protection (PCLP)
❐ Single-point fault protection
CY8CLEDAC02應用:
❐ Dimmable offline LED driver
❐ Dimmable LED replacement lamps
❐ Dimmable LED luminaires
[!--empirenews.page--]
圖1.CY8CLEDAC02邏輯方框圖
圖2.簡化的CY8CLEDAC02應用方框圖
圖3.調光輸入的CY8CLEDAC02 LED驅動電路圖
采用CY8CLEDAC02 120VAC 17W可調光LED驅動器參考設計
圖4. 120VAC 17W可調光LED驅動器參考設計電路圖
120VAC 17W可調光LED驅動器參考設計材料清單(BOM):
The CY8CLEDAC02 is a high performance offline LED driver, designed to interface directly with most conventional phase cut based wall dimmers. The device uses proprietary digital control technology to provide automatic detection of dimmer type(leading or trailing edge). It automatically generates dimming signals for LED loads and has the ability to dim down to 2%. It modulates LED brightness using a linear dimming scheme and switches to a PWM based dimming scheme for output current levels lower than 20% of the full load current. In PWM mode optimized dimming frequencies in the range of 900 Hz result in zero visible flicker.
At the heart of a CY8CLEDAC02 based system is the chopping circuit which provides the load necessary to enable correct wall dimmer operation. It also improves PF when there is no dimmer on the line.
The devices’ proprietary primary side sensing enables tight LED current regulation and eliminates the need for secondary feedback circuitry. No opto-couplers are necessary to meet UL isolation requirements; enabling flyback conversion with automatic isolation.
The CY8CLEDAC02 operates in quasi-resonant mode to achieve high efficiency. This mode of operation helps minimize external component count and simplifies EMI design, lowering the total bill of material cost.
The device’s cycle-by-cycle adaptive digital regulation uses critical discontinuous conduction mode (CDCM) when driving LED loads. The control algorithm for cycle-by-cycle regulation has internal compensation for guaranteed system phase and gain margins; requiring no external components for loop compensation.
The CY8CLEDAC02 has full featured circuit protection not normally available with other primary-side control solutions. The built-in protection includes output overvoltage protection (OOVP), output short circuit protection (OSCP), overtemperature protection (OTP), current-sense resistor short protection (CSSP), and peak current limit protection (PCLP). It also enables automatic LED brightness adjustment to compensate for temperature drift by simply connecting a NTC resistor to the VT pin.
CY8CLEDAC02主要特性:
■ AC offline input range from 80 to 277 VAC
■ Up to 25W output power range
■ Intelligent wall dimmer detection:
❐ Leading edge (R, RL) dimmers
❐ Trailing edge (RC, RLC) dimmers
❐ No dimmer
■ Wide dimming range from 2 to 100%
■ Resonant control to achieve high efficiency (85% without dimmer)
■ Meets harmonic requirement with high power factor (0.7 without dimmer)
■ Primary-side sensing eliminates opto-isolators
■ Tight LED current regulation (typically < + 2.5%)
■ Low startup current (typically 10 A)
■ Low startup time (typically 0.5s with active startup)
■ Multiple protection features:
❐ Output overvoltage protection (OOVP)
❐ Output short circuit protection (OSCP)
❐ Overtemperature protection (OTP)
❐ Current-sense resistor short protection (CSSP)
❐ Peak current limit protection (PCLP)
❐ Single-point fault protection
CY8CLEDAC02應用:
❐ Dimmable offline LED driver
❐ Dimmable LED replacement lamps
❐ Dimmable LED luminaires
[!--empirenews.page--]
圖1.CY8CLEDAC02邏輯方框圖
圖2.簡化的CY8CLEDAC02應用方框圖
圖3.調光輸入的CY8CLEDAC02 LED驅動電路圖
采用CY8CLEDAC02 120VAC 17W可調光LED驅動器參考設計
圖4. 120VAC 17W可調光LED驅動器參考設計電路圖
120VAC 17W可調光LED驅動器參考設計材料清單(BOM):
下載文檔本站聲明： 本文章由作者或相關機構授權發布，目的在于傳遞更多信息，并不代表本站贊同其觀點，本站亦不保證或承諾內容真實性等。需要轉載請聯系該專欄作者，如若文章內容侵犯您的權益，請及時聯系本站刪除。
換一批
延伸閱讀
上海概倫電子股份有限公司是一家具備國際市場競爭力的EDA企業，擁有領先的EDA關鍵核心技術，致力于提高集成電路行業的整體技術水平和市場價值，提供專業高效的EDA流程和工具支撐。公司通過EDA方法學創新，推動集成電路設計和...
關鍵字： EDA 集成電路 芯片設計據業內消息，近日深圳市發改委發布了一則關于促進半導體與集成電路產業高質量發展的若干措施的意見征求稿，文件中的主要幾條談及了促進半導體集成電路產業的領域支持、核心技術突破等多項內容，這也表達了發改委對半導體集成電路技術依賴...
關鍵字： 深圳市 發改委發布文件 半導體 EDA據一份與員工分享的財務報告，TikTok母公司字節跳動(Bytedance)去年的運營虧損增至70億美元以上，是此前一年的逾三倍。該報告提供了一個罕見的了解這家非上市公司備受關注的財務狀況的機會。報告顯示，字節跳動在20...
關鍵字： 字節跳動 EDA TIKTOK TE[電子與信息學報]
北京大學+北京微電子技術研究所最新綜述：當機器學習遇見EDA | 《電子與信息學報》佳文速遞
隨著硅工藝發展接近物理極限，用來刻畫工藝演進速度的摩爾定律也開始被打破，半導體行業迎來了后摩爾時代。然而集成電路芯片產業并沒有因此而停滯發展，現場可編程門陣列（Field Programmable Gate Array...
關鍵字： EDA 機器學習隨著美國對華限制可用于GAAFET的EDA 設計工具，凸顯EDA 在芯片設計關鍵角色。由于目前EDA 產業高度集中，前三大廠商以美商為主。預計臺積電2nm制程也將采用美商針對GAAFET 架構的EDA軟件。另據臺媒報道，...
關鍵字： 聯發科 鴻海 EDA數十年中，摩爾定律演進推動著芯片制造工藝和設計架構發生了翻天覆地的變化，隨著晶體管尺寸逼近物理極限，未來先進設計及工藝向著延續摩爾定律(More Moore)、超越摩爾定律(More than Moore)和新型器件(B...
關鍵字： EDA 國產EDA 自研芯片
廠商專欄
熱門文章
- 稚暉君機器人公司否認借殼上市 回應：只是收購了一家上市公司
- 尊湃芯片竊密案宣判：創始人獲刑6年，華為勝訴！
- 突發！美國科技巨頭上海AI研究院解散
- 深入解讀MOS管
- 美國服“軟”！解除EDA出口限制，芯片設計不再卡脖子
- 深度解析阻抗匹配網絡——L型、pi型與T型
- 小華四開關BUCK-BOOST參考設計助力雙向DC/DC電源開發
- 阿里最新17位合伙人名單出爐：9人退出 無新增
- CAN總線的工作原理是什么？CAN總線和LIN總線有什么區別？
- 您的低電流測量精度如何？
編輯精選
更多
論壇活動
更多
論壇熱帖
- 1拖3光耦問題
- GD32EmbeddedAI模型轉換報錯
- AI編程踩坑隨筆
- DC12V的轉向燈 經典測試不通過，4KV就掛了，怎么整改
- 嵌入式高薪崗位有哪些?
- N32WB031_STB板子下載報錯RDDI-DAP Error
- 為智能語音設備點亮“視界”：我在啟英泰倫CI230X上成功驅動LCD屏
- 這款電池充電器 在51M和140M超標 一般是哪里的原因？以下措施用了還是不行
- HC32L021 IAP 偏移做了映射，能跳轉但進不了APP程序中斷
- 有沒有做電子產品經理的，都是用什么軟件和上那些論壇進行學習、進階，指導
技術子站
更多
資料下載
更多
技術學院
- TrendForce集邦咨詢:英偉達嘗試調升HBM4規格，預期2026年SK海力士仍是最大供應商
- TrendForce集邦咨詢: 預估2025年全球筆電出貨年增2.2%，東南亞產能持續擴張
- TrendForce集邦咨詢: AI推理需求導致Nearline HDD嚴重缺貨，預計2026年QLC SSD出貨有望趁勢爆發
- TrendForce集邦咨詢: 庫存調整結束，2Q25全球智能手機生產總數達3億支，季增約4%
- TrendForce集邦咨詢: 2Q25全球牽引逆變器裝機量年增19%，增程式電動車助力SiC機種普及
- TrendForce集邦咨詢: AI與通用型服務器驅動需求，2Q25前五大企業級SSD品牌廠營收季增12.7%
- TrendForce集邦咨詢：預估2025年iPhone 17系列出貨量小幅成長，Air系列將引領產品線變革
- TrendForce集邦咨詢: 國際大廠加速投入，預估2030年AR眼鏡出貨量達3,210萬臺
